Sunday, March 1, 2009

Mud and Sticks II

I would like to conclude my slide show of pictures from the cob house project of a few years back. I guess the word 'house' might be stretching it, perhaps 'hut' is more appropriate as the square footage was only around 250.

The work took until late October of that year, and we moved in right after the roof was on. At that point, all the cob was still relatively damp and that first winter was not exactly the coziest. Here's a picture from the inside soon after we occupied:


The opposite side of the wall pictured above, a wall defined by a long bowed log which formed the wall plate, can be seen in this picture:


This was shortly prior to shingling the roof, thus the plastic.

We also put a cob floor into the place; this is similar to the wall material except that the clay content is a bit higher, and the straw was chopped very finely:


The cob floor experiment did not go so well however, as it never quite dried properly, was too soft to walk on, and added a lot of extra moisture to the inside of a rather humid space. So, after a month or two, I laid down a moisture barrier, a 2x4 floor and sheeted it in plywood. I'm sure the cob floor, which is still intact under the ply, would have been fine in the long run, however we had to deal with the problem on the spot, so it was a bit of a shame that the experiment didn't work out as intended.

After a winter and a spring, the summer finally brought the warmth and dryness that allowed the building to cure properly:


The walls dried out after that summer and we never really took them any further. The normal practice might be a final plaster coat or two, then possibly whitewashing with a lime-based plaster (there are numerous possibilities and plaster recipes), but we just left it pretty much as we had completed it. In this next picture, you can see that one wall still has bits of straw sticking out - this was eventually given a rough plaster coat. The project had been an exhausting one, and my partner of the time, though she had worked really hard through the course of the project, once over, she had lost all interest in doing any more, and I felt the same, wanting to put my energies into other areas:


In a large measure, I was hesitant to show pictures of this project on a public forum like this - - in fact, I long felt somewhat embarrassed about the building, since it is so much cruder than the work I like to do and am capable of executing. I've managed to overcome my embarrassment however.

I ended up living in that building for a couple more years, with electricity and phone service but no running water. Although the architecture of this little hut is quite primitive, in a similar manner to the observation from temple carpenter Nishioka that I mentioned in the previous post, I found the experience of being in the space altogether pleasing. To lay down in bed and gaze up at the slender bowed logs, wire tires, and rough planking was very satisfying, a diverse and absorbing view. What you saw was what you got, and it was no mystery how the roof was supported- you could see the structure from within. It was a cute little place, and part of its charm came from the crudity.

I found that the cob walls, despite their lack of refinement in surface finish and unsophisticated profile, really gave me some new building insights I hadn't considered before. You see, clay is a wonderful material to have in a wall. In the summer, the inside of the space was pleasantly cooler than the outside, and in the winter, once the interior fireplace had been on a while, the 'flywheel effect' allowed the cob to retain heat and keep the inside constantly warmer and dryer than outside. It was inexpensive to heat. I have huge respect for clay as a material as a result of that living experience. It is exceptional as a controller of moisture in a space, and 'breathes in a way, gradually taking on moisture and gradually losing it, in response to the climate. It's non-toxic and low tech, and has low-embedded energy, unlike the conventional building materials we use. Cob works in a diverse range of climates as well. And as for durability, there are 500 year-old cob buildings in Ireland - in fact in wattle and daubed half-timbered English buildings it is the timbers that fail before the earthen wall materials in most cases. So, cob and light clay building techniques associate strongly to the long-view building strategy.

And anyone can do it - make cob - if of good physical health, thus the opportunity for client participation - owner-builder participation - in the building process is there.

I sold that property and moved to Massachusetts. The new owner was a woman who had spent time in Japan and had a strong interest in pottery - in fact the cob hut is now her pottery studio. Though I first built the house with no building permit, it has since received an engineer's approval and is fully legal. In fact, there have been a number of earthen walled structures erected in various parts of B.C. and the building code is beginning to become a bit more open to natural building, which is a very positive development in my opinion.

I'm not sure I would build in cob again, given the slow-moving and laborious nature of the process, however clay is most definitely going to be a part of the next house I build, and I have given a lot of thought in the meantime to a system of building which integrates the timber frame with the light clay wall, and think I have come to some innovative, low-tech ideas in terms of how to accomplish that, and with a high level of refinement. Maybe one day I'll get a chance to build something like that.

2 comments:

  1. Chris,

    Its a great house and a great story. Its sad in a way that you gave it up- that house is 100% you and part of what you were and represented then (if not now). I think (whether you were trying to or not) you showed that even in our age of refinement and "ease" of production, you could stick it (rather convincingly) to the man (convention). While its as much human nature (yours) to want to do it all yourself, its as much human nature (the rest) to want something "turn key" with as little inconvenience as possible (nature and the environment be damned).

    Steve

    ReplyDelete
  2. Thanks Steve. Those comments remind me of the Doctor's desk project, funny enough. After I started in on the desk, a piece of land was cleared behind the RCMP station for a new house for a police constable. I walked past the site everyday on my way to and from my workshop.

    Not only was that building project, a typical suburban 2000 sq.ft. box, started after I had commenced working on the desk, but it was finished, landscaped, the new cop moved in complete with the dog house and German Shepherd parked on the front lawn -and I was STILL working on the desk!

    And I know that my desk will be around long after that house has been crushed and scraped, but it still amazes me to think of how rapid the modern building process has become, and how 'normal' and 'rational' it is. This is what people expect these days. It's all about 'fast', but not so much, often, about 'good'.

    House-building in the 1800's was often a multi-year affair, by way of comparison.

    Thanks again for the support Steve!

    ReplyDelete

All comments are moderated, so if you're planning to spam this, know now that your clicking and pasting is in vain. I do read the comments before posting, so your mission is doomed from the outset. All this time and effort trying to put your inane spam onto blogs -- is this how you want to spend your time on earth?

Please do me the courtesy of appending your name to your comment, even if posting under the 'anonymous' option. No name = deleted.

Comments NOT accepted include:

-those containing links unrelated to blog content
-spam of any kind, or ham for that matter
-did I mention that attempted spam postings will be non-starters?